Specs of the Freightliner Business Class M2. The Freightliner M2 106 is a medium-duty truck. It has extended cab and crew cabs available. Its specs are as follows: Class: 6/7; Horsepower: 200-350; Torque: Up to 1150 pounds per foot; Engines: Cummins B6.7, Cummins L9, Detroit DD5, Detroit DD8. M2 106 $37,195 USD $43,725 USD Miles: 307,248. Freightliner Business Class M2 Maintenance Manual.pdf. FREIGHTLINER Sprinter 2015 Operating Instructions Manual.pdf. Heavy-Duty Trucks Maintenance Manual.
Content .. 891011 ..
25–02 Eaton Fuller Clutch
Release Cross-Shaft Lubricating
IMPORTANT: This maintenance operation per- tains only to vehicles equipped with mechanical (not hydraulic) linkages.
The clutch release cross-shaft is equipped with two grease fittings in the transmission clutch housing. See
and
. Wipe the dirt from the grease
fittings and lubricate with multipurpose chassis grease.
25–03 Clutch Hydraulic Fluid
Level Checking
WARNING
Use only approved clutch hydraulic fluid (DOT 4 brake fluid) in the clutch hydraulic system. Do not mix different types of brake fluid. The wrong fluid will damage the rubber parts of the system, caus- ing loss of clutch function and the risk of serious personal injury.
CAUTION
Do not allow the fluid level in the reservoir to go below the MIN line. If too much air enters, the hy- draulic system will not operate correctly, and the clutch could be damaged.
If the fluid level is below the MIN line, fill the reser- voir with DOT 4 brake fluid until the level reaches the MAX line. See
25–04 Clutch Hydraulic Fluid
Changing
Replace the clutch hydraulic fluid every two years to ensure clutch function is reliable and correct. Use the
f250048a
1
2
10/19/93
1.
Clutch Release Cross-Shaft
2.
Grease Fitting
Fig. 3, Cross-Shaft Grease Fitting, Left Side
f260146a
05/27/93
Fig. 4, Cross-Shaft Grease Fitting, Right Side
12/10/2001
1
2
3
4
5
6
f250580
1.
Reservoir Cap
2.
Reservoir
3.
Pedal Unit
4.
Master Cylinder
5.
Hydraulic Hose
6.
Slave Cylinder
Fig. 5, Clutch Components
Clutch
25
Business Class M2 Maintenance Manual, August 2015
25/2
Regular chassis maintenance is imperative to keeping your coach safe and reliable for years to come. We recommend that you proactively schedule and record service at optimum intervals and have routine maintenance performed at a Freightliner location.
To use the maintenance sheets below to their full advantage, you’ll want to download the complete RV chassis maintenance manual first. The page number in the “MOP” column on the far right of each maintenance sheet will direct you to the full explanation of required inspection or service in the chassis maintenance manual.
As always, if you have any questions about your vehicle’s maintenance needs, give us a call at 800.FTL.HELP.
Chassis Maintenance Manual 6,000 Mile / 6 Month
Engine
Inspect Drive Belt
Check Support Fasteners
Change Oil and Filter (see engine manufacturer's manual)
Air System
Inspect Charge Air Cooler (CAC) and clean if needed
Drain Air Tanks
Inspect Air Conditioner Component
Electrical
Check Alternator, Battery and Starter Connections
Change and Clean Ground Cables
Radiator
Inspect Radiator Cap
Inspect Radiator Coolant Freeze Points
Inspect Radiator SCA Levels
Inspect Radiator Hose Routing (for Chaffing and Leaks)
Mechanical Fan Drive
Change Gearbox Oil
Transmission
Change Fluid and Filter (if required by Allison)
Inspect Hose Routing for Chaffing and Leaks
Throttle Pedal
Lubricate Pivot Pin
Suspension
Check Fastener Torque
Check Height Control Valve
Lubricate ZF IFS
Check Suspension U-Bolt Torque
Inspect V-Ride Rear Suspension
Lubricate Knuckle Pin†
Inspect and Lubricate Tie-Rod End†
Check All-Axle Alignment
Inspect Wheel End
Change Oil on Oil-Filled Hubs (front and tag axle)
Check Axle Seals for Leaks
Change Axle Lubricant and Clean Magnetic Plug (Detroit and Meritor Axles)
Check Axle Breather
Tires, Brakes and Drivelines
Check Wheel Nut
Check Tire Pressure
Inspect and Lubricate Driveline
Inspect Brake System Valves
Inspect Air Dryer and Air Lines for Proper Routing, Chaffing and Leaks
Lubricate Camshaft Bracket Bushing
Lubricate Slack Adjuster
Lubricate Foot Brake Actuator
Inspect Bendix Hydro-Max® Brake System (Front-Engine Only)